公司新聞
冷瀝青混合料的特點與注意使用
來源：http://huatts.com/ 日期：2022-06-10
冷瀝青混合料在明顯環境和溫度下都可以隨時對路面坑槽進行修補，有可以長期存放，隨時取用不造成資源浪費，并且使用過程中不會有黑煙，廢水，廢料的產生，已逐漸在國道、省道、市政道路上得到推廣和應用。那么冷瀝青混合料的特點與注意使用是怎樣的？
Cold asphalt mixture can repair pavement pits and grooves at any time under any environment and temperature. It can be stored for a long time and used at any time without causing waste of resources. In addition, there will be no black smoke, waste water and waste materials in the process of use. It has been gradually promoted and applied in national, provincial and municipal roads. So what are the characteristics and attentions of cold asphalt mixture?
冷瀝青混合料的特點
Characteristics of cold asphalt mixture
適用天氣和環境
Applicable weather and environment
冷補適用的環境溫度范圍寬，可以在-30至50之間適用，冷補防水性能，在雨雪天氣和積水坑穴都可以施工。
The applicable ambient temperature range of cold patching is wide, and it can be applied between -30 and 50. The cold patching waterproof performance can be constructed in rainy and snowy weather and ponding pits.
施工簡單
Simple construction
使用冷補材料，修補時無需粘層油，備料可隨取，隨用不需要重型施工機械，可根據路面的不同修補情況采用沖擊壓實，人工壓實等。
Cold patching materials are used. There is no need to stick layer oil during patching. Materials can be taken at any time. Heavy construction machinery is not required. Impact compaction and manual compaction can be adopted according to different patching conditions of the pavement.
修補質量
Repair quality
冷補料具有*的抗老化和粘結性功能，修補后的抗穴，不易產生脫落，龜裂等不良現象，不需要重新修補。
The cold patching material has the anti-aging and bonding functions of * and the repaired anti hole is not easy to fall off, crack and other undesirable phenomena, so it does not need to be repaired again.
容易保存
Easy to save
金歐特冷補料成品常溫下可露天存放兩年之久，袋裝密封成品存放時間更長。
The finished products of Jinou special cold replenishment can be stored in the open air for two years at normal temperature, and the storage time of bagged sealed products is longer.
立即通車
Open to traffic immediately
用冷補維修材料補過的區域無需封閉交通，可立即通車，大大緩解因道路修補施工而造成的交通堵車。
The area filled with cold repair materials does not need to be closed to traffic, and can be opened to traffic immediately, greatly alleviating the traffic jam caused by road repair construction.
綠色環保
Green environmental protection
冷補材料生產和使用不會產生粉塵和黑煙，且材料不溶于水，因而不會污染大氣和水，有利于環境保護。
The production and use of cold patching materials will not produce dust and black smoke, and the materials are insoluble in water, so they will not pollute the atmosphere and water, which is conducive to environmental protection.
適用用途
Applicable use
冷補材料與瀝青混凝土、水泥混凝土、金屬表面等不同基質的材料均有良好的粘結力，可廣泛應用與高速公路、一般公路、市政道路、機場道路、橋梁等多種路面的修補與養護。
Cold patching materials have good adhesion with asphalt concrete, cement concrete, metal surface and other materials with different substrates, and can be widely used in the repair and maintenance of highways, general highways, municipal roads, airport roads, bridges and other pavement.
冷瀝青混合料注意使用
Pay attention to the use of cold asphalt mixture
濟南瀝青料廠家提醒可以將坑槽內部清理干凈，沒有雜物和石屑積水等，將冷料包裝拆袋倒出攤鋪平整，攤鋪高度不要與路面持平，而是要高出一點，一般實際攤鋪高度是坑槽深度1.2~1.5，這樣比路面稍高一點，在機器壓實和車輛突出之后會與路面逐漸持平。如坑槽深度超過5cm，應分層填補，逐層壓實，每層3-5cm。
Jinan asphalt manufacturer reminds that the pit and groove can be cleaned without debris, stone chips and water. The cold material package can be unpacked and poured out for paving. The paving height should not be equal to the road surface, but higher. Generally, the actual paving height is 1.2~1.5 of the pit depth, which is slightly higher than the road surface. It will be gradually equal to the road surface after machine compaction and vehicle compaction. If the depth of the pit exceeds 5cm, it shall be filled in layers and compacted layer by layer, 3-5cm for each layer.
壓實過程要遵循“先四周，再中間”，使用壓實工具反復壓實三次以上，這樣整體壓實度可得到保障，修補過的坑槽才不會輕易松散。
The compaction process shall follow the principle of "first around, then in the middle", and the compaction tool shall be used for repeated compaction for more than three times, so that the overall compactness can be guaranteed, and the repaired pits and grooves will not be loosened easily.
冷瀝青混合料修補過的坑槽有非常強的抗老化和粘結性能。修補后的坑槽不易產生脫落，龜裂等不良現象，不需重復修補，修補過的坑槽可用立即開放交通。施工后的剩余材料不要打開包裝，在陰涼干燥，遠離火源的地方可存儲至兩年以上。
The repaired pits and grooves of cold asphalt mixture have very strong anti-aging and bonding properties. The repaired pits and grooves are not easy to fall off, crack and other adverse phenomena, and do not need to be repaired again. The repaired pits and grooves can be opened to traffic immediately. The remaining materials after construction shall not be unpacked. They can be stored in a cool and dry place away from the fire source for more than two years.
更多相關內容的了解就來關注我們網站huatts.com吧！
For more information, please visit our website www.ycgjglcl Com!
公司地址：濟南市商河縣賈莊鎮民營經濟創業園
公司名稱:永誠廣建公路材料（山東）有限公司 
備案號：